Subscribe

Sign up for free

  • Get quick access to your favorite articles

  • Manage alerts on breaking news and favorite drivers

  • Make your voice heard with article commenting.

Autosport Plus

Discover premium content
Subscribe

Toyota diagnoses issue that cost #7 car Le Mans 24 Hours victory

Toyota drivers Mike Conway, Kamui Kobayashi and Jose Maria Lopez lost victory in last weekend's Le Mans 24 Hours because of an incorrectly wired system of tyre pressure sensors

The Japanese manufacturer has revealed that the system on the #7 Toyota TS050 HYBRID was still showing that the right front tyre pressure was dropping after that wheel had already been changed with an hour of the race remaining.

This was because the sensors on each corner of the car had been wired up incorrectly to the antenna that communicates with the pits.

Toyota had initially stated that the drama that handed victory to the sister car driven by Fernando Alonso, Sebastien Buemi and Kazuki Nakajima had been the result of an issue with one of the sensors.

Toyota Motorsport GmbH technical director Pascal Vasselon told Autosport: "The reason was that the antenna was wrongly connected.

"It was wired in the wrong way and was not a sensor problem.

"It is serious, as all mistakes are."

Lopez was leading the sister Toyota driven by Nakajima by more than two minutes when the system of tyre pressure sensors indicated a right-front puncture.

Because the puncture hit late in the lap, Lopez was still able to resume with a healthy lead after the wheel was changed, only for the system to continue to indicate that the same tyre was punctured.

Vasselon explained that Toyota had asked its Michelin engineer to check the pressure of the tyre that had been taken off the car and that is was found to be normal.

The team then changed all four tyres when Lopez made it back to the pits for the second time.

The left rear was subsequently found to be the tyre that had sustained the puncture.

The second lap of the 8.48-mile Le Mans circuit with the punctured left rear took Lopez nearly six minutes and resulted in him rejoining over a minute behind the sister car.

Toyota praises Lopez

Vasselon praised Lopez for keeping a cool head when it became clear that the incorrect tyre had been replaced at the initial pitstop.

"What normally happens when something like this happens is that the driver is pissed off, goes too fast, the tyre delaminates and damages the car.

"We have speed limits for a range of tyre pressures and Jose Maria perfectly respected them.

"The team and the driver especially showed a lot of maturity in a situation where we were very close to a big drama."

Lopez admitted after the race that he was crying in the car on the second lap with the puncture.

Be part of the Autosport community

Join the conversation
Previous article Late BoP change left Aston Martin to just "drive around" at Le Mans
Next article Aston Martin set to give WEC hypercar to customer teams too

Top Comments

There are no comments at the moment. Would you like to write one?

Sign up for free

  • Get quick access to your favorite articles

  • Manage alerts on breaking news and favorite drivers

  • Make your voice heard with article commenting.

Autosport Plus

Discover premium content
Subscribe